|
06-22-2019, 02:46 PM
|
#1
|
Member
Brand: Thor Motor Coach
Model: Outlaw 37RB
State: British Columbia
Posts: 36
THOR #14822
|
Overhead Bunk slipping down
2017 Thor Outlaw 37RB.
Overhead bunk on drivers side will not hold, keeps slipping down.
__________________
|
|
|
06-22-2019, 03:05 PM
|
#2
|
Senior Member
Brand: Thor Motor Coach
Model: Hurricane 31S
State: Texas
Posts: 4,182
THOR #6411
|
All the Thor MC front bunks move down while traveling unless the locking pins are installed.
__________________
Jim & Roy Davis
2016 Hurricane 31S
1961 Rampside in tow
|
|
|
06-22-2019, 03:45 PM
|
#3
|
Member
Brand: Thor Motor Coach
Model: Outlaw 37RB
State: British Columbia
Posts: 36
THOR #14822
|
This happens as I am dropping the bunk, left side seems to fall almost as the right side comes down under control. Eventually the bunk stops as it's offset is so far off.
__________________
|
|
|
06-22-2019, 03:47 PM
|
#4
|
Site Team
Brand: Thor Motor Coach
Model: ACE 27.1
State: Florida
Posts: 14,382
THOR #7035
|
That would depend of which type of overhead bunk you have. Ours folds and is held up by magnets; there are no locking pins.
__________________
Ted & Melinda
2016 ACE 27.1
2016 Chevy Sonic Toad - Selling
2020 Chevy Colorado Z71 Trail Runner Toad
2024 Chevrolet Trax 2RS - Soon 2B TOAD
|
|
|
06-22-2019, 04:02 PM
|
#5
|
Member
Brand: Thor Motor Coach
Model: Outlaw 37RB
State: British Columbia
Posts: 36
THOR #14822
|
This bunk has the pins which we use when the bunk is in the stow position. The unit is a Schwintek, Lippert Controls.
__________________
|
|
|
06-22-2019, 04:32 PM
|
#6
|
Senior Member
Brand: Still Looking
Model: Travato
State: Florida
Posts: 2,475
THOR #1765
|
Sounds like you have a drivers side slide motor problem. Have you tried the resync procedure? If that doesn’t work, You may have a bad motor or wire disconnect to that motor.
__________________
|
|
|
06-22-2019, 04:38 PM
|
#7
|
Member
Brand: Thor Motor Coach
Model: Outlaw 37RB
State: British Columbia
Posts: 36
THOR #14822
|
Thanks, do you know where I can find the procedure?
__________________
|
|
|
06-22-2019, 04:46 PM
|
#8
|
Senior Member
Brand: Thor Motor Coach
Model: Vegas 24.1
State: Florida
Posts: 892
THOR #5313
|
Everyhing is online. I searched and printed all the specific operating manuals and keep in RV. The Thor manual is generic and may not cover every section in detail. Also Mr. Felkers manual is in there. There is a big sticker with list of items and serial numbers in RV closet.
I will not mention binders/folders.
__________________
|
|
|
06-22-2019, 04:46 PM
|
#9
|
Senior Member
Brand: Still Looking
Model: Travato
State: Florida
Posts: 2,475
THOR #1765
|
Search for schwintec in YouTube and there are a bunch of great videos. This is the one that directly addresses what could be your problem. Once you get it in sync, remember to never extend or retract it part way and to continue to press the button for 3-5 seconds until you hear the motors completely stop.
https://youtu.be/hSafAnjxIV4
__________________
|
|
|
06-22-2019, 05:49 PM
|
#10
|
Senior Member
Brand: Thor Motor Coach
Model: Hurricane 29M
State: Texas
Posts: 2,724
THOR #11781
|
My Hurricane bunk did that too, I resynced and it works fine now.
__________________
Lt Keefer
2018 Hurricane 29M
CHF, Saf-T-Plus, SumoSprings
|
|
|
06-22-2019, 07:56 PM
|
#11
|
Senior Member
Brand: Thor Motor Coach
Model: 2013 ACE 30.1
State: Alberta
Posts: 1,410
THOR #2631
|
Quote:
Originally Posted by 16ACE27
That would depend of which type of overhead bunk you have. Ours folds and is held up by magnets; there are no locking pins.
|
I think that the ACE may be the only (could be wrong) coach that uses a different front bunk drop system, but they still use the schwintek controller and motors I think. Pretty sure my controller is on the passenger side near the ceiling, but I don't see an easy panel removal to access it. There are panels on the front ceiling corners that give access to the motors and bed drop mechanisms. Don't use the front bunk anyway.
__________________
|
|
|
06-22-2019, 08:26 PM
|
#12
|
Senior Member
Brand: Thor Motor Coach
Model: Hurricane 29M
State: Arkansas
Posts: 515
THOR #11266
|
Quote:
Originally Posted by Lt Keefer
My Hurricane bunk did that too, I resynced and it works fine now.
|
I have resynced mine several times, and the passenger side still works down some. Think the motor may need to be replaced?
__________________
Jeff and Melissa - Roodie and Jaxson
US Navy Vet - Good Sam Life Member 804274173
2019 Hurricane 29M
2015 Ford Explorer XLT Toad
|
|
|
06-22-2019, 08:32 PM
|
#13
|
Senior Member
Brand: Still Looking
Model: Travato
State: Florida
Posts: 2,475
THOR #1765
|
You might try disconnecting the passenger side motor from the controller to see if the drivers side motor is working at all. Also check to see if the wires are connected to the motor at both the motor and controller ends, These RVs shake rattle and roll down the road and sometimes things shake loose.
__________________
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
|