Front cap leaks

[Sullyd59]

Originally Posted by Jimbo56

Do not rely on the dealers say so that it feels dry. Go check yourself.

Still at dealership big rain coming tomorrow I have an access panel in the bed for inspection purposes.( they made it) I can monitor it.

[Steve Kaplan]

I have a 2012 Four Winds 25C. Water leaks in the cab at both passenger and driver side, rear upper corners at the bulkhead. No water coming down the cap top or sides, not wet on the bed area. I think it's leaking at the seal between the overhang and the cab. Is this seal replaceable? Has anyone had this leak?

[Sullyd59]

Picture of leak in awning

[CHS]

Originally Posted by bjslifeline

I have a 2018 Fourwinds 28z. Ours had a leak just above the drivers seat. Apparently there was missing sealant on an outside seem and it was running along a seem on the bottom of the over head bunk. Had it fixed and not a problem since. Now we found a leak behind our bedroom headboard so we will be resealing all of the rear possible entries come spring before we leave for traveling. Just remember there will ALWAYS be issues when you drive a house down roads from bumping and shaking. Hopefully the issues are not overwhelming and you can enjoy your trips. Good Luck!

Buy some 6 inch Eternabond and clean then cover the lap seals on both front and rear of the roof. Will nver have another issue with them.
https://www.amazon.com/dp/B07BRMRMWX...ing=UTF8&psc=1

https://www.youtube.com/watch?v=spdYGUtZVcU

[mcr1010]

I'll 2nd that. Did it on all my RV's and never had a problem.

[Sullyd59]

After seal tech test showed some air bubbles in recently repaired front cap molding ,they are going to remove and re seal with hengs 5050 butyl and reseal the molding with proflex . 6 hrs labor at 160.00 an hour. Thor is partially reimbursing me due to it being an independent repair shop .