RV News RVBusiness 2021 Top 10 RVs of the Year, plus 56 additional debuts and must-see units → ×

Go Back   Thor Forums > Thor Tech Forums > Maintenance and Repair
Click Here to Login
Thread Tools Display Modes
Old 09-21-2017, 03:39 PM   #1
Senior Member
Brand: Thor Motor Coach
Model: Freedom Elite 29fe
State: Florida
Posts: 674
THOR #4656
Heads up for outside kitchens

After a few months and very little usage, I was just doing a routine wash job and general clean up. After washing, I opened the outside kitchen to get a beer from the refer. Everything from the counter top on down was wet. The small pull out under the sink was full of water.

I first thought it was the gasket around the opening, which was installed with the utmost Thor efficiency, twisted and coming apart in places as are most of the other compartments. I bought some automotive weather strip and removed and installed the new properly. Then I closed the access door and gently ran some water down the side above the door opening. When I opened the door, once again everything from the counter top on down was soaked.

The sealant around the compartment looked good, I mean it's only a few months since new and has traveled very little. But, it was the sealant. If you pored water from a cup against the side above the opening, you could see it disappear. So I resealed it with some very good sealant. Not silicone and not the water soluble junk from the home stores, but rather some clear stuff that needs mineral spirits to remove and clean up. Next day, no water leaks.

My conclusion to this problem is two fold. One, not sealed properly at the factory. Two, the gas struts that support the door when open are very powerful, as they should be. I open and close that compartment several times a week in the driveway, keep cold beer in there. I think this frequent opening and closing against the strong gas struts puts stress on the hinge area which is part of the upper flange around the door. This causes the sealant to separate.

nosticks is offline   Reply With Quote
Old 09-21-2017, 03:51 PM   #2
Senior Member
Tupelo Kid's Avatar
Brand: Thor Motor Coach
Model: ACE
State: Georgia
Posts: 214
THOR #9143
Interesting. I will need to keep close watch on ours.
Thanks for the heads up.

Tupelo Kid is offline   Reply With Quote
Old 09-21-2017, 06:34 PM   #3
Senior Member
Brand: Still Looking
State: Tennessee
Posts: 297
THOR #7227
I have almost the same problem but my top weatherstripping had twisted up and was in very bad shape. Like you I replaced the weatherstrip but have not noticed the other problem. Will definitely give it a good examination this weekend.
JamJanTan is offline   Reply With Quote
Old 09-22-2017, 01:38 AM   #4
Senior Member
Brand: Thor Motor Coach
Model: Four Winds
State: Ontario
Posts: 263
THOR #9081
Well you left out the most important part. Was the beer still cold?
2018 Four Winds 31Y
Peterrrr is offline   Reply With Quote

leaks, outdoor kitchen, sealant

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off

» Featured Campgrounds

Reviews provided by


This website is not affiliated with or endorsed by Thor Industries or any of its affiliates. This is an independent, unofficial site.

All times are GMT. The time now is 08:27 AM.

Powered by vBulletin® Version 3.8.8
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
Content Relevant URLs by vBSEO 3.6.0 PL2