No winterization needed... just routine maintenance.
Maintenance Steps
1. Check fluid in reservoir every 12 months. If fluid is a clear red color, do not change. If fluid is milky, pink and murky and not clear red in color, drain reservoir and add new fluid. Hydraulic fluid in reservoir should be changed a minimum of every 5 years.
Note: Check the fluid only when all the jacks are fully retracted.
Note: When checking the hydraulic fluid level, fill to within 1/4" to 1/2" of fill spout.
2. Inspect and clean all power unit electrical connections every 12 months. If corrosion is evident, spray power unit electrical connections with electrical contact cleaner.
3. Remove dirt and road debris from jacks as needed.
4. If jacks are down for extended periods, it is recommended to spray exposed jack rods with a silicone lubricant every 3 months for protection. If the unit is located in a salty environment, it is recommended to spray the rods every 4 to 6 weeks.
Fluid Recommendation
ATF with DexronŽ III or MerconŽ V or a blend of both is recommended by Lippert Components, Inc. For a list of approved fluid specifications, see TI-188. To obtain this Technical Information sheet on-line, go to:
https://lci-support-doc.s3.amazonaws...cd_0002088.pdf
Note: In colder temperatures (less than 10 °F) the jacks may extend and retract slowly due to the fluid's molecular nature. For cold weather operation, fluid specially formulated for low temperatures may be desirable.
Thor Forums
